Optimization of Algal–Bacterial Biomass for Sustainable Treatment of Textile Industry Wastewater
Keywords:
Textile wastewater, Scenedesmus, Bacillus subtilis, COD removal, BOD reduction, TDS and TSS removal.Abstract
Textile wastewater represents a major environmental challenge due to its high organic load, salinity, suspended solids, and resistance to conventional physico-chemical treatment processes, which are often energy-intensive and generate excessive secondary sludge. Integrated algal–bacterial consortia offer a sustainable alternative by coupling bacterial biodegradation with algal nutrient uptake and photosynthetic oxygen production. In this study, the treatment performance of algal, bacterial, and integrated algal–bacterial sludge systems was evaluated using real textile wastewater collected from the inlet of the effluent treatment plant at Quetta Textile Mills, Pakistan. Indigenous microalgal strains (Chlorella vulgaris and Scenedesmus) and a bacterial strain (Bacillus subtilis) were cultivated and applied under controlled laboratory conditions. Treatment efficiency was assessed at hydraulic retention times of 2, 4, 6, and 8 h by monitoring pH, chemical oxygen demand (COD), biological oxygen demand (BOD), total dissolved solids (TDS), and total suspended solids (TSS). Among all tested systems, the Chlorella vulgaris–Bacillus subtilis consortium exhibited the highest treatment efficiency, achieving approximately 95% overall pollutant removal within 8 h. COD and BOD were reduced from 1486 to 90 mg L⁻¹ and 800 to 45 mg L⁻¹, respectively, while TDS and TSS decreased from 9000 to 1033 mg L⁻¹ and 720 to 60 mg L⁻¹. The integrated system also demonstrated excellent sludge settleability, with a sludge volume index (SVI) of 30–35 mL g⁻¹, indicating efficient solid–liquid separation. The superior performance of the algal–bacterial consortium was attributed to synergistic interactions, where algal oxygen production enhanced aerobic bacterial degradation, while bacterial metabolism supplied CO₂ and nutrients to support algal growth. These findings highlight the potential of algal–bacterial sludge systems as an eco-friendly, energy-efficient, and rapid treatment strategy for high-strength textile wastewater, with strong applicability for industrial-scale wastewater management, reuse, and integration into circular bioeconomy frameworks.
References
AlMomani, F., & Örmeci, B. (2020). Assessment of algae-based wastewater treatment in a hot climate region: Treatment performance and kinetics. Process Safety and Environmental Protection, 141, 140-149.
Bolognesi, S., Cecconet, D., Callegari, A., & Capodaglio, A. G. (2021). Combined microalgal photobioreactor/microbial fuel cell system: performance analysis under different process conditions. Environmental Research, 192, 110263.
Calijuri, M. L., Do Couto, E. D. A., Assemany, P. P., Ribeiro, V. J., Lorentz, J. F., Castro, J. D. S., ... & Henriques, B. S. (2025). Microalgae-Based Wastewater Treatment and Biomass Valorization: Insights, Challenges, and Opportunities from 15 Years of Research. ACS omega, 10(42), 49273-49299.
Dalvi, V., Chawla, P., & Malik, A. (2021). Year-long performance assessment of an on-site pilot scale (100 L) photobioreactor on nutrient recovery and pathogen removal from urban wastewater using a native microalgal consortium. Algal Research, 55, 102228.
El-Sheekh, M. M., Moghazy, R. M., Hamoud, M. M., & Elshobary, M. E. (2025). Comparative Phycoremediation Performance of Two Green Microalgal Strains Under Four Biomass Conditions for Industrial Wastewater Treatment. Psychology, 5(4), 53.
Ferreira, A., Reis, A., Vidovic, S., Vladic, J., Gkelis, S., Melkonyan, L., ... & Gouveia, L. (2020). Combining microalgae-based wastewater treatment with biofuel and bio-based production in the frame of a biorefinery. In Grand challenges in algae biotechnology (pp. 319-369). Cham: Springer International Publishing.
Fidiastuti, H. R., Lathifah, A. S., Amin, M., & Utomo, Y. (2020, March). Studies of Bacillus subtilis NAP1 to degrade BOD, COD, TSS, and pH: The indigenous bacteria in Indonesian batik wastewater. In Journal of Physics: Conference Series (Vol. 1511, No. 1, p. 012060). IOP Publishing.
Hasan, H. A., Muhamad, M. H., Ji, B., Nazairi, N. A., Jiat, K. W., Sim, S. I. S. W. A., & Poh, A. F. M. S. (2023). Revolutionizing wastewater treatment with microalgae: Unveiling resource recovery, mechanisms, challenges, and future possibilities. Ecological Engineering, 197, 107117.
Hasanath, A., Panigrahi, A., Chaitanya, N. K., & Chatterjee, P. (2025). Treatment of beverage wastewater using microalgae: A focus on COD removal, biomass production, and lipid accumulation. Bioresource Technology Reports, 102467.
Javed, F., Rashid, N., Fazal, T., Hafeez, A., & Rehman, F. (2023). Integration of real industrial wastewater streams to enhance Chlorella vulgaris growth: nutrient sequestration and biomass production. Water, Air, & Soil Pollution, 234(3), 164.
Josa, I., & Garfi, M. (2023). Social life cycle assessment of microalgae-based systems for wastewater treatment and resource recovery. Journal of Cleaner Production, 407, 137121.
Kumar, V., Gururani, P., Parveen, A., Verma, M., Kim, H., Vlaskin, M., ... & Rindin, K. G. (2023). Dairy Industry wastewater and stormwater energy valorization: effect of wastewater nutrients on microalgae-yeast biomass. Biomass Conversion and Biorefinery, 13(15), 13563-13572.
Kusmayadi, A., Leong, Y. K., Yen, H. W., Huang, C. Y., Dong, C. D., & Chang, J. S. (2020). Microalgae‐microbial fuel cell (mMFC): an integrated process for electricity generation, wastewater treatment, CO2 sequestration and biomass production. International Journal of Energy Research, 44(12), 9254-9265.
Li, L., Gao, K., Yang, M., Zheng, Q., Zhang, M., & Deng, X. (2023). Challenges and potential solutions of microalgae-based systems for wastewater treatment and resource recovery. Frontiers in Bioengineering and Biotechnology, 11, 121-228.
Liu, X. Y., & Hong, Y. (2021). Microalgae-based wastewater treatment and recovery with biomass and value-added products: a brief review. Current Pollution Reports, 7(2), 227-245.
Malik, S., Kishore, S., Prasad, S., & Shah, M. P. (2022). A comprehensive review of emerging trends in industrial wastewater research. Journal of Basic Microbiology, 62(3-4), 296-309.
Morais, E. G., Sampaio, I. C. F., Gonzalez-Flo, E., Ferrer, I., Uggetti, E., & García, J. (2023). Microalgae harvesting for wastewater treatment and resources recovery: A review. New Biotechnology, 78, 84-94.
Nagi, M., He, M., Li, D., Gebreluel, T., Cheng, B., & Wang, C. (2020). Utilization of tannery wastewater for biofuel production: New insights on microalgae growth and biomass production. Scientific reports, 10(1), 1530.
Nobre, M. L., Tavares, D., Fraga, C., Oliveira, B., Dias, M., Mesquita, S., ... & Pires, J. C. (2024). Techno-economic analysis of a circular microalgal approach for enhanced wastewater treatment and resource recovery in Northern Portugal. Journal of Cleaner Production, 434, 140389.
Nowruzi, B., Shishir, M. A., Porzani, S. J., & Ferdous, U. T. (2022). Exploring the interactions between algae and bacteria. Mini Reviews in Medicinal Chemistry, 22(20), 2596-2607.
Pancha, I. (2023). Algal–Bacterial Interactions in the Environment: Emerging Applications. Algae Refinery, 148-160.
Santos, A. M., Deprá, M. C., dos Santos, A. M., Cichoski, A. J., Zepka, L. Q., & Jacob-Lopes, E. (2020). Sustainability metrics on a microalgae-based wastewater treatment system. Desalination and Water Treatment, 185, 51-61.
Sathinathan, P., Parab, H. M., Yusoff, R., Ibrahim, S., Vello, V., & Ngoh, G. C. (2023). Photobioreactor design and parameters essential for algal cultivation using industrial wastewater: A review. Renewable and Sustainable Energy Reviews, 173, 113096.
Sátiro, J., Cunha, A., Gomes, A. P., Simões, R., & Albuquerque, A. (2022). Optimization of microalgae–bacteria consortium in the treatment of paper pulp wastewater. Applied Sciences, 12(12), 5799.
Torres-Franco, A., Passos, F., Figueredo, C., Mota, C., & Muñoz, R. (2021). Current advances in microalgae-based treatment of high-strength wastewaters: challenges and opportunities to enhance wastewater treatment performance. Reviews in Environmental Science and Bio/Technology, 20(1), 209-235.
Ummalyma, S. B., Sahoo, D., & Pandey, A. (2021). Resource recovery through bioremediation of wastewaters and waste carbon by microalgae: a circular bioeconomy approach. Environmental Science and Pollution Research, 28(42), 58837-58856.
Wang, Z., Li, Z., Gao, C., Jiang, Z., Huang, S., Li, X., & Yang, H. (2025). Bacillus subtilis as an excellent microbial treatment agent for environmental pollution: A review. Biotechnology Journal, 20(4), e70026.
Xu, S., Li, Z., Yu, S., Chen, Z., Xu, J., Qiu, S., & Ge, S. (2024). Microalgal–bacteria biofilm in wastewater treatment: Advantages, principles, and establishment. Water, 16(18), 2561.
You, N., Deng, S., Wang, C., Ngo, H. H., Wang, X., Yu, H., ... & Han, J. (2023). Review and opinions on the research, development and application of microalgae culture technologies for resource recovery from wastewater. Water, 15(6), 1192.
Zabochnicka, M. (2022). Industrial wastewater as a growth medium for microalgal biomass for a sustainable circular bioeconomy. Applied Sciences, 12(20), 10299.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2026 International Journal of Agriculture Innovations and Cutting-Edge Research (HEC Recognised)
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
BWO Research International
15162394 Canada Inc.,
Kitchener, ON, N2G2B3,
Canada